Got a 04 Sportsman 500 that wasnt running- owner said it needed a stater and a new battery. It ran rough (been sitting out in the weather for a while). A friend and I started by adding a new battery and it would start barely with the choke and his hand over the air-filter. I decided to install the new battery in the holder on the side. We had it on the rack because the old on was still in the bike. I tried to be nifty by turning the battery to put the terminals in an easier spot to get to, but forgot to reverse the cables too. In a sentence, I reversed the positive and negative on the battery like a dummy. Polaris Ranger Service Manual Download Free FullPolaris ranger service manual free online is available in our book collection an online access to it is set as public so you can download it instantly. Our books collection hosts in multiple locations, allowing you to get the most less latency time to. Download this manual. -- preview this manual 2005-2007 Polaris Ranger 500 service manual Factory repair manual for the 2005-2007 Polaris Ranger 500. Manual covers complete tear down and rebuild, pictures and parts diagrams, torque specs, maintenance, troubleshooting and more. The BEST electronic Polaris Ranger manuals available for download. Manual listed below are full factory service manuals with hundreds of pages containing step. When we discovered my mistake and corrected it, we turned on the bike, but the display did not light up and the key did not turn on the starter. Jumping the solenoid worked the starter, so we thought the solenoid just burned up when I reversed the pos and neg. New solenoid and no difference. What have I burned up? The BEST electronic Polaris Ranger manuals available for download. Polaris Ranger Manuals. 1998 Polaris Ranger Series Repair and Maintenance Manual. Mobile Device Ready Manual* (Works with most devices. Polaris Ranger 500 Service Manual Download FreeAlso, the shifter does not seem to do anything in the trans. It slides back and forth like its stripped in the trans. Any help would be appreciated!! Polaris Ranger Service Manual Download Free Windows 7I think the biggest issue right now is the electrical. I've never done this before but after reading a few thread I decided to check my valves for the first time and to my surprise it was much easier than I thought. My bike is a 2005 Sp 500 HO. Ms bus controller driver download. I first pulled the seat and the right side panel off, and that's it! It wasn't too bad to get at. Next I pulled the spark plug out and removed both the head cover ( 8-8mm bolts) [ATTACH]1021[/ATTACH] then the side cam cover (5-8mm bolts). [ATTACH]1023[/ATTACH] Also remove the plug in the recoil cover (14mm bolt) to see the timming marks. [ATTACH]1022[/ATTACH] Next I turned the engine over with the pull cord untill it was at TDC of the compression stroke. The best was to tell that your at TDC of the compression stroke is to rotate the engine until the timing marks are parallel to rocker cover gasket surface.
0 Comments
Leave a Reply. |
AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |